|
|
 NITROGEN GENERATORSNitrogen generators use either membrane or pressure-swing-adsorption (PSA) technologies. Membrane generators made by Balston, a division of Parker, produce up to 99.5% pure, commercially sterile nitrogen at dewpoints to -58[degrees]F from compressed air. They use proprietary membrane-separation technology to divide air into two streams: one 95 to 99.5% pure nitrogen, the ingersollrandgasaircompressor other oxygen-rich with carbon dioxide and other trace gases.Compressed air flows through ingersollrandgasaircompressor bundles of individual, hollow fibers made of semipermeable membranes. Each fiber has a perfectly circular cross section and a uniform bore through its center. Because the fibers are so small, a great many can be packed into a limited space, providing enough surface area to produce a relatively high-volume ingersollrandgasaircompressor flow of nitrogen. THE MOTORMost hermetic compressors use induction motors cooled by either liquid or suction-gas refrigerant. Induction motors have copper windings that, when alternating current is run through them, create the magnetic fields that cause the motor to turn. These copper windings are bulky, adding size and weight to the compressor.Two-pole, 60-Hz induction motors operate at approximately 3,600 rpm. A higher number of revolutions per minute can be obtained by increasing the frequency. Compressors that require higher shaft speeds tend to use gears. While gears are a proven technology, they create noise and vibration, consume power, and require lubrication.The magnet-bearing compressor features a synchronous permanent-magnet brushless DC motor with a completely integrated variable-frequency drive ingersollrandgasaircompressor (VFD). The stator windings found on conventional induction motors are replaced with a permanent-magnet rotor. Alternating current from the inverter energizes the armature windings. The stator (excitation) and rotor (armature) change places. No commutator brushes are required. The motor and key electronic components are internally refrigerant-cooled, so no ingersollrandgasaircompressor special cooling is required for the VFD or the motor. Buy a gas air compressor with us and save a TON of cash. Our selection of cheap gas air compressors is second to none.
|