|
|
 The use of permanent magnets instead of rotor windings makes the motor smaller and lighter than induction motors. Using magnetic-bearing northstar82cfm90psi50hpaircompressormodel45920 technology, a 75-ton compressor weighs 265 lb--about northstar82cfm90psi50hpaircompressormodel45920 one-fifth the weight of a conventional compressor.A variable-speed drive (VSD) is required for the motor to operate. The VSD varies the frequency between 300 and 800 Hz, which provides a compressor-speed range from 18,000 to 48,000 rpm. This avoids a gear set. The VSD is integrated into the compressor housing, avoiding long leads and allowing key electronic components to be refrigerant-cooled. The VSD also acts as a soft starter; as a result, the compressor has an extremely low startup in-rush current: less than 2 amps, compared with 500 to 600 amps for a traditional 75-ton, 460-v screw compressor with a cross-the-line starter. NITROGEN GENERATORSNitrogen generators use either membrane or pressure-swing-adsorption (PSA) technologies. Membrane generators made by Balston, a division of Parker, produce up to 99.5% pure, commercially sterile nitrogen at dewpoints to -58[degrees]F from compressed northstar82cfm90psi50hpaircompressormodel45920 air. They use proprietary membrane-separation technology to divide air into two streams: one 95 to 99.5% pure nitrogen, the other oxygen-rich with carbon dioxide and other trace gases.Compressed air flows through bundles of individual, hollow fibers made of semipermeable membranes. Each fiber has a perfectly circular cross section and a uniform bore through its center. Because the fibers are so small, northstar82cfm90psi50hpaircompressormodel45920 a great many can be packed into a limited space, providing enough surface area to produce a relatively high-volume flow of nitrogen. Oxygen, water vapor, and other trace gases permeate the membrane fiber and are discharged through a permeate port. Nitrogen stays within the hollow fibers and flows through an outlet port.Balston PSA nitrogen generators produce up to 99.95% pure, compressed nitrogen at dewpoints northstar82cfm90psi50hpaircompressormodel45920 to -40[degrees]F from nearly any compressed-air supply. The generators continually transform air into nitrogen at safe, regulated pressures without operator attention.PSA generators use a combination of filtration and PSA technologies to create nitrogen.Compressed air is prefiltered to remove all contaminants down to 0.1 micron. The gas separation process preferentially adsorbs oxygen northstar82cfm90psi50hpaircompressormodel45920 over nitrogen using carbon-molecular sieve (CMS). At high pressures, the CMS has a greater affinity for oxygen, carbon dioxide, and water vapor than it does at low pressures. By raising and lowering pressure within the CMS bed, all contaminants are captured and released, leaving the CMS unchanged. This process lets nitrogen pass through. Depressurizing the CMS releases adsorbed oxygen and other contaminant gases to the atmosphere. Buy a gas air compressor with us and save a TON of cash. Our selection of cheap gas air compressors is second to none.
|